Ezgo ST 400 CARB Owner's Manual Page 44
- Page / 164
- Table of contents
- BOOKMARKS
Rated. / 5. Based on customer reviews
Page 24
OPERATION AND SERVICE INFORMATION
Read all of Section B and this section before attempting any procedure. Pay particular attention to all Notes, Cautions and Warnings.
B
Fig. 35 Oil Viscosity Chart
If vehicle is to be stored over winter months, it can be stored
with old oil left in engine. The oil should be changed as part of
spring maintenance. This will remove any moisture that has
accumulated during storage.
Be aware that engine fluids may be hot and
contact to the skin may cause severe burns.
Wear rubber gloves to protect skin from expo-
sure to the old oil and degreaser.
The oil should be changed with engine warm. Park vehicle on a
level surface, engage parking brake and remove key. Place a
drain pan under engine. Wipe top of the engine clean with a
cloth (Ref. Fig. 36 on page 24). Remove the oil fill cap.
Fig. 36 Cleaning Top of Engine
Clean the area around filter. Using a filter wrench, strap
wrench or other suitable wrench (A), remove the filter
(B) from the engine and allow the oil to drain. The ‘O’
rings may remain on engine (A) or filter (B) (Ref. Fig. 37
on page 24)
Fig. 37 Remove Oil Filter
Inspect the filter. Make sure the ‘O’ ring is not left on the
engine surface.
Fig. 38 Inspect Oil Filter
Be careful of hot oil when drained. It may be
hot enough to burn you severely
Drain the oil by removing the drain plug found at the
rear of the engine base. Remove using a 3/4" wrench.
At the first oil change, small metal chips and lint may be
found. This is normal, resulting from the break-in period.
Inspect the filter at every oil change. The presence of
large metal chips could indicate possible damage to the
engine.
-20 0 20 40 60 80 100
-30 -20 -10 0 10 20 30 40
C
F
0
0
10W-3010W-30
10W-4010W-40
HEAVY DUTY WORK
LIGHT DUTY WORK
(AIR TEMPERATURE)
10W-3010W-30
Oil Fill Cap
- GASOLINE POWERED VEHICLES 1
- NUTZFAHRZEUGE MIT BENZINMOTOR 1
- 606909-DE 1
- BATTERIES 2
- CONTAIN LEAD 2
- OWNER’S MANUAL 3
- AND SERVICE GUIDE 3
- GENERAL INFORMATION 4
- TABLE OF CONTENTS 5
- SAFETY INFORMATION 10
- BEFORE INITIAL USE 21
- CONTROLS AND INDICATORS 22
- OPTIONAL WINCH 23
- Pull out 24
- Clutch Knob 24
- LOCKED OUT 24
- Incorrect 26
- COMMON SENSE OPERATION 27
- ENVIRONMENTAL CONCERNS 27
- VEHICLE CAPACITY 27
- MODIFICATIONS TO VEHICLE 28
- LOAD BED 28
- Manual Load Bed Latch 29
- Pull Up to Release 29
- STORAGE 30
- OPERATING THE VEHICLE 31
- 1" Min 34
- (2.5 cm) 34
- Ref Ftl 1S 34
- VEHICLE CLEANING AND CARE 35
- Ref Whi 3S 37
- FUSE REPLACEMENT 38
- TRANSPORTING VEHICLE 39
- SERVICE AND MAINTENANCE 40
- TIRE INSPECTION 42
- FOUR CYCLE ENGINE 43
- Oil Fill Cap 44
- 3/8" (1 cm) Maximum 46
- Deflection (New Belt) 46
- 1/2" (1.3 cm) Maximum 46
- Deflection (Existing Belt) 46
- Ref Bpt 2S 47
- AIR INTAKE AND COOLING FINS 48
- Ref Air 2 49
- 0.7 - 0.8 mm 50
- (.028” - .031”) 50
- CAPACITIES AND 51
- REPLACEMENT PARTS 51
- HARDWARE 51
- Ref Tsp 1 52
- GENERAL SPECIFICATIONS 55
- LABELS AND PICTOGRAMS 63
- VEHICLE WARRANTIES 71
- DOMESTIC WARRANTY 72
- Appendix B - 3 73
- Appendix B - 4 74
- VEHICLE WARRANTIES - FEDERAL 75
- DECLARATION OF CONFORMITY 77
- (EUROPE ONLY) 77
- BEDIENUNGS- UND 83
- WARTUNGSHANDBUCH 83
- ALLGEMEINE INFORMATIONEN 84
- SICHERHEITSINFORMATIONEN 90
- HINWEISE: 100
- VOR DEM ERSTMALIGEN EINSATZ 101
- VORSICHT 102
- OPTIONALE WINDE 104
- Ref Wdt 1 105
- Ref Wca 2 106
- Korrekte 106
- Ref Wps 2 106
- UMSICHTIGER BETRIEB 107
- UMWELTHINWEISE 107
- FAHRZEUG-LADEKAPAZITÄT 107
- VERÄNDERUNG DES FAHRZEUGS 108
- LADEFLÄCHE 108
- Ref Gss 1 109
- AUFBEWAHRUNGSFÄCHER 110
- LASTKORB (WENN VORHANDEN) 111
- GEWEHRHALTER (WENN VORHANDEN) 111
- BETRIEB DES FAHRZEUGS 112
- REINIGUNG UND PFLEGE DES 115
- FAHRZEUGS 115
- REPARATUR 116
- Ref Liv 4S 116
- Radmontage 117
- Unidirektionale Reifen 117
- SICHERUNGSERSATZ 118
- TRANSPORT DES FAHRZEUGS 119
- WARTUNG UND BETRIEB 119
- Ref Isl 1S 120
- REGELMÄSSIGER WARTUNGSPLAN 121
- REIFENINSPEKTION 122
- VIERTAKTMOTOR 123
- Seite 24 124
- BREMSEN 127
- LUFTEINLASS UND KÜHLRIPPEN 128
- BEFESTIGUNGSELEMENTE 131
- Seite 32 132
- Seite 33 133
- Seite 34 134
- ALLGEMEINE TECHNISCHE DATEN 137
- AUFKLEBER UND SYMBOLE 145
- FAHRZEUGGARANTIE 153
- FAHRZEUGGARANTIE - CALIFORNIA 155
- FAHRZEUGGARANTIE - FEDERAL 157
- ÜBEREINSTIMMUNGSERKLÄRUNG 159
- (NUR IN EUROPA) 159
- • Muskelzucken 163
- UK and Europe 164
- Ransomes Jacobsen Limited 164
Related products and manuals for Cars Ezgo ST 400 CARB
Cars Ezgo JAC 4000 User Manual
(1 pages)
(1 pages)
Cars Ezgo ST SPORT CARB User Manual
(104 pages)
(104 pages)
Cars Ezgo JAC 4000 User Manual
(1 pages)
(1 pages)
© 2020, manymanuals.com. All rights reserved. | 1.533 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals