Ezgo ST 400 CARB Owner's Manual Page 23
- Page / 164
- Table of contents
- BOOKMARKS
Rated. / 5. Based on customer reviews
OPERATION AND SERVICE INFORMATION
Page 3
Repair and Service Manual
Read all of Section B and this section before attempting any procedure. Pay particular attention to all Notes, Cautions and Warnings.
B
B
If oil level is below ADD mark on dipstick, add oil to bring
level to FULL mark. Drive vehicle a short distance and
check oil pressure. If oil light does not come on, con-
tinue to use vehicle.
ACCELERATOR PEDAL
Unintentional movement of the accelerator
pedal will release the park brake and may
cause the vehicle to move which could result in
severe injury or death.
With the key switch ‘ON’, depressing the accelerator
pedal starts the engine. When the pedal is released, the
engine will stop (Ref. Fig. 5 on page 3). To stop the vehi-
cle more quickly, depress the service brake. If key
switch is ‘ON’ and park brake is set, depressing the
accelerator inadvertently will release the park brake and
will cause the vehicle to move which could cause severe
injury or death.
Depressing the accelerator pedal will release the park
brake if it is engaged. This is a feature to assure the
vehicle is not driven with the park brake engaged.
Depressing the accelerator pedal is not the preferred
method of releasing the park brake.
Depressing the lower section of the brake pedal is the pre-
ferred method of releasing the park brake to assure the long-
est service life of brake components.
COMBINATION SERVICE AND PARK BRAKE
PEDAL
The brake pedal incorporates a park brake feature (Ref.
Fig. 5 on page 3). To engage, push down on the upper
section of the pedal until it locks in place. The park
brake will release when the service brake pedal is
depressed. Use the lower section of the brake pedal to
operate the service brake system.
HORN
The horn is operated by pushing the horn button located
on the floor to the left of the brake pedal (Ref. Fig. 5 on
page 3).
12 VOLT POWER OUTLET
Overuse of accessories may drain the battery and leave
insufficient reserve to start the vehicle.
A 12 volt power outlet, rated at 15 amps, is located to
the left side of the key/light switch (Ref. Fig. 6 on page
3). It provides constant power for accessories equipped
with a 12 volt plug.
TERRAIN
The vehicle is designed for use on improved roads (but
not on public highways). The vehicle may also be used
on established trails or open terrain that is free from
stumps, large rocks or holes.
The vehicle should not be used to cross water.
OPTIONAL WINCH
ST 400 ONLY
The ST 400 may be equipped with an optional winch.
Read, understand and follow all of the following informa-
tion on the operation and use of winch before attempting
to operate it.
Fig. 5 Accelerator, Brake and Horn
Fig. 6 12 Volt Power Outlet
Service
Brake
Accelerator
H
O
R
N
Horn
Park
Brake
R
ef Abh 1S
12V Power
Outlet
ON
OFF
FUEL
F
E
Ref Pow 1
- GASOLINE POWERED VEHICLES 1
- NUTZFAHRZEUGE MIT BENZINMOTOR 1
- 606909-DE 1
- BATTERIES 2
- CONTAIN LEAD 2
- OWNER’S MANUAL 3
- AND SERVICE GUIDE 3
- GENERAL INFORMATION 4
- TABLE OF CONTENTS 5
- SAFETY INFORMATION 10
- BEFORE INITIAL USE 21
- CONTROLS AND INDICATORS 22
- OPTIONAL WINCH 23
- Pull out 24
- Clutch Knob 24
- LOCKED OUT 24
- Incorrect 26
- COMMON SENSE OPERATION 27
- ENVIRONMENTAL CONCERNS 27
- VEHICLE CAPACITY 27
- MODIFICATIONS TO VEHICLE 28
- LOAD BED 28
- Manual Load Bed Latch 29
- Pull Up to Release 29
- STORAGE 30
- OPERATING THE VEHICLE 31
- 1" Min 34
- (2.5 cm) 34
- Ref Ftl 1S 34
- VEHICLE CLEANING AND CARE 35
- Ref Whi 3S 37
- FUSE REPLACEMENT 38
- TRANSPORTING VEHICLE 39
- SERVICE AND MAINTENANCE 40
- TIRE INSPECTION 42
- FOUR CYCLE ENGINE 43
- Oil Fill Cap 44
- 3/8" (1 cm) Maximum 46
- Deflection (New Belt) 46
- 1/2" (1.3 cm) Maximum 46
- Deflection (Existing Belt) 46
- Ref Bpt 2S 47
- AIR INTAKE AND COOLING FINS 48
- Ref Air 2 49
- 0.7 - 0.8 mm 50
- (.028” - .031”) 50
- CAPACITIES AND 51
- REPLACEMENT PARTS 51
- HARDWARE 51
- Ref Tsp 1 52
- GENERAL SPECIFICATIONS 55
- LABELS AND PICTOGRAMS 63
- VEHICLE WARRANTIES 71
- DOMESTIC WARRANTY 72
- Appendix B - 3 73
- Appendix B - 4 74
- VEHICLE WARRANTIES - FEDERAL 75
- DECLARATION OF CONFORMITY 77
- (EUROPE ONLY) 77
- BEDIENUNGS- UND 83
- WARTUNGSHANDBUCH 83
- ALLGEMEINE INFORMATIONEN 84
- SICHERHEITSINFORMATIONEN 90
- HINWEISE: 100
- VOR DEM ERSTMALIGEN EINSATZ 101
- VORSICHT 102
- OPTIONALE WINDE 104
- Ref Wdt 1 105
- Ref Wca 2 106
- Korrekte 106
- Ref Wps 2 106
- UMSICHTIGER BETRIEB 107
- UMWELTHINWEISE 107
- FAHRZEUG-LADEKAPAZITÄT 107
- VERÄNDERUNG DES FAHRZEUGS 108
- LADEFLÄCHE 108
- Ref Gss 1 109
- AUFBEWAHRUNGSFÄCHER 110
- LASTKORB (WENN VORHANDEN) 111
- GEWEHRHALTER (WENN VORHANDEN) 111
- BETRIEB DES FAHRZEUGS 112
- REINIGUNG UND PFLEGE DES 115
- FAHRZEUGS 115
- REPARATUR 116
- Ref Liv 4S 116
- Radmontage 117
- Unidirektionale Reifen 117
- SICHERUNGSERSATZ 118
- TRANSPORT DES FAHRZEUGS 119
- WARTUNG UND BETRIEB 119
- Ref Isl 1S 120
- REGELMÄSSIGER WARTUNGSPLAN 121
- REIFENINSPEKTION 122
- VIERTAKTMOTOR 123
- Seite 24 124
- BREMSEN 127
- LUFTEINLASS UND KÜHLRIPPEN 128
- BEFESTIGUNGSELEMENTE 131
- Seite 32 132
- Seite 33 133
- Seite 34 134
- ALLGEMEINE TECHNISCHE DATEN 137
- AUFKLEBER UND SYMBOLE 145
- FAHRZEUGGARANTIE 153
- FAHRZEUGGARANTIE - CALIFORNIA 155
- FAHRZEUGGARANTIE - FEDERAL 157
- ÜBEREINSTIMMUNGSERKLÄRUNG 159
- (NUR IN EUROPA) 159
- • Muskelzucken 163
- UK and Europe 164
- Ransomes Jacobsen Limited 164
Related products and manuals for Cars Ezgo ST 400 CARB
Cars Ezgo JAC 4000 User Manual
(1 pages)
(1 pages)
Cars Ezgo ST SPORT CARB User Manual
(104 pages)
(104 pages)
Cars Ezgo JAC 4000 User Manual
(1 pages)
(1 pages)
© 2020, manymanuals.com. All rights reserved. | 1.362 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals